The driver knows that sometimes the temperature gradually cools down and the climate has changed significantly. In summer and autumn, forklifts should pay special attention to maintenance. It is recommended that you maintain the following conditions for the maintenance of electric forklifts this quarter.
External maintenance of the vehicle: In the autumn morning and at dusk, there are more dewdrops. The appearance of the forklift is often very wet. If the body has significant scratches, it should be painted in time to avoid the rust and rust on the scratched parts. Due to the acid rain and the erosion of summer rain, the summer light is direct, the body paint surface will inevitably oxidize. In the cold season, it is quite good to make the appearance of the forklift clean, maintain and paint.
Tire protection: Tires play an important role in the safe handling of forklifts. In the summer, due to the high temperature, you should always check the tire pressure, you can not make the tire pressure too high, otherwise, there will be a risk of puncture, and in the autumn, due to the relatively low temperature, the tire will supply pressure and remain within the scope of the rule. The pressure of the air inside, at the same time, should also look at the scratched tires, due to the simple rubber knot in the autumn and winter and the brittle tires are easy to leak, the tires, and even often mixed in the tires.
Cabin protection: Check the engine oil, brake fluid and antifreeze in the engine compartment. Is the oil quantity enough, whether it is changing, whether to replace the circulation, whether the oil is like the blood of the vehicle, it is necessary to change the cycle to ensure the circulation of the oil circulation. Maintenance of the brake system: The temperature difference between autumn and night is large, and the body is swollen and contracted. It is often necessary to check whether the brake is weak, drift, and whether the brake pedal is changed. It is necessary to clean the brake system of the entire pipeline.
Warm duct and fan protection: If your forklift is equipped with a warm duct or fan, after a summer operation, or prepared for the coming cold winter, the fall is quite suitable for viewing these devices, the wind is normal Whether it is the aging of the exhaust gas detection line, etc., if there are any problems, it can be dealt with in time. Maintenance of the intake pipe or intake grille: Check if there are any debris in these parts. If there is any debris, you can blow off the dust with compressed air. In addition, if the engine is cooled, whether the above area can be used with a water gun from the inside out Cleaning.
Pre：Forklift hydraulic torque converter common 5 fault
Next：Troubleshooting for forklift lifts that cannot be raised to the top
